Abdul-Zahoor MD, FCPS*, Nor Azlina MD, MSc**
*Consultant Anesthesiologist
King Khaled Eye Specialist Hospital, P. O. Box 7191, Riyadh 11462 (Saudi Arabia)
**Consultant Anesthesiologist
National Heart Institute, 145, Jalan Tun Razak, 50400, Kuala Lumpur (Malaysia)
Correspondence: Dr. Abdul-Zahoor MD, FCPS, Consultant Anesthesiologist, King Khaled Eye Specialist Hospital, P. O. Box 7191, Riyadh 11462 (Saudi Arabia); Phone: +966 509003709; Fax No: +966 1 4821908; E-mail: armanzahoor@hotmail.com or armanzahoor@yahoo.com
ABSTRACT
Background: The reported incidence of reintubation in patients who were weaned from mechanical ventilation after cardiac surgery is 6.6%4 in a retrospective study, but little work has been done prospectively to find out the incidence and causes for reintubation in a cardiac surgical ICU. We conducted this study to find out incidence and the causes of endotracheal reintubation in patients who were electively ventilated after open heart surgery and were extubated after fulfilling preset criteria for extubation.
Methodology: A total of 1229 consecutive patients were included in the study. On arrival to ICU after cardiac surgery, all patients were electively ventilated with standardized ventilatory parameters. Routine monitoring of all patients was done and patients were extubated once they met the criteria for extubation. The patients, who met the reintubation criteria, were reintubated and the reason(s) noted. Once they stabilized and fulfilled the extubation criteria, they were extubated.
Results: A total of 47(3.82%) patients required reintubation after weaning from the ventilation during the study period, and in 5(10.63%) patients out of these, reintubation was needed more than once. We found a higher incidence of reintubation, 11.84 % and 10.63%, in patients after single and double valve replacement surgery respectively. The incidence was much lower (2.14%) among coronary artery bypass grafting (CABG) patients.
Conclusion: The patients undergoing valve replacement surgery are more prone to reintubation in postoperative period as compared to CABG patients. Impending respiratory failure, cardiovascular (hemodynamic) instability and impaired conscious level are the common indications for reintubation.
Key Words: Extubation failure; coronary artery bypass grafting; reintubation; cardiac surgery intensive care unit; open heart surgery; valve replacement
Citation: Zahoor A, Azlina N. Endotracheal reintubation in post-operative cardiac surgical patients. Anaesth Pain & Intensive Care 2011;15(1):25-29.
INTRODUCTION
Endotracheal reintubation is not uncommon among critically ill patients after open heart surgery1. The overall incidence for reintubation in a general surgical intensive care unit is generally considered 4%, but varies dramatically between 1-13%, depending on the underlying disease process2. Similarly a 10% incidence has been reported in 745 consecutive admissions in medical ICU patients that were mechanically ventilated for a minimum of 6 hours3. The reported incidence of reintubation in patients who were weaned from mechanical ventilation after cardiac surgery is 6.6%4 in a retrospective study but little work has been done to find out the incidence and causes for reintubation in a cardiac surgical ICU prospectively.
Reintubation is not only associated with increased duration of mechanical ventilation but also the ICU and hospital length of stay5. Reintubation is known to be an independent cause, which adds to the mortality; patients who required reintubation have poor prognosis with a mortality rate exceeding 30-40%1, irrespective of the cause for reintubation. The major causes of reintubation are usually related to respiratory or cardiovascular system but could be multi-factorial6 and may possibly be prevented, to some extent, by improving the care7.
We studied the incidence and the causes of endotracheal reintubation in patients who were electively ventilated after open heart surgery and were extubated after fulfilling the preset criteria for extubation.
METHODOLOGY
After approval by the institutional review board of our hospital, all adult patients, who underwent open heart surgery and were electively ventilated after the surgery in the post-cardiac surgery intensive care unit (CICU), were included in the study. It was a descriptive study. The data was prospectively collected for a period of seven months, from January to July 2008. A total of 1229 patients, admitted during this period, were enrolled in the study.
Routine monitoring of all patients was done including ECG, arterial oxygen saturation (SaO2), end tidal carbon dioxide (EtCO2), central venous pressure and invasive arterial blood pressure. Pulmonary artery pressure, pulmonary capillary wedge pressure or left atrial pressure were monitored where indicated (Table 3).
Arterial blood gases were checked hourly for the first four hours and were subsequently repeated after every change in the ventilatory parameters. Urine output and surgical bleed through the chest drains was measured on an hourly basis. Hematocrit was aimed to be kept at 30 % or above and appropriate transfusion was given when indicated.
All patients, on arrival to ICU, were put on standardized ventilatory parameters unless indicated otherwise. They were initially put on volume controlled or pressure controlled mode (Table 3). A positive end expiratory pressure (PEEP) of 5 cmH2O or more was added where indicated. An inspired oxygen fraction (FiO2) of ≥50% and a tidal volume of 10ml/kg body weight was set to all patients. The ventilatory parameters were adjusted according to the results of arterial blood gases (ABG’s).
An early extubation was aimed in all patients but no time schedule was fixed like a fast track. All patients were extubated without any delay, when they met the preset criteria for extubation (Table 1).
Table 1: Pre-set Criteria for extubation
Respiratory:
SIMV rate ≤ 6 breaths/min; Pressure support ≤10cmH2O; PEEP ≤ 5cmH2O; FiO2 ≤ 50%.
SaO2 ≥ 90% on Fio2 ≤ 50%, PaO2 ≥ 80mmHg on Fio2 ≤ 50%, PaCo2 30-45mmHg
Cardiovascular:
Conscious level:
Vasoactive drugs: Dopamine≤10 µg/Kg/min; Dobutamine ≤ 10 µg/kg/min; Epinephrine ≤ 0.05µg/min; Norepinephrine ≤ 0.2 µg/kg/min; Glyceral Trinitrate (GTN) ≤ 5 µg/kg/min; Milrinone ≤ 0.5 µg/kg/min and Sodium nitroprusside (Nepride) ≤ 2 µg/kg/min Miscellaneous:
|
A consideration was also given to the frequency of requirement and dosage of inotropic, chronotropic, vasodilator and/or vasoconstrictor drugs used. Extubation was delayed if a patient was on more than three drugs at that same time. Diaphoresis, confusion, stroke, renal failure or compromised renal functions and anxiety were also considered as causes for extubation delay. Patients were re-intubated when indicated according to preset criteria for reintubation (Table 2).
Table 2: Pre-set criteria for re-intubation
Respiratory:
↑in PaCO2 ≥ 10 mmHg/hr, ↓in the pH ≥ 0.10/hr, PaO2 ≤ 60 mmHg or SaO2 ≤ 90% on FiO2 ≥ 50%
Cardiovascular:
Impaired conscious level: Miscellaneous:
|
The data for the indications for reintubation were collected under the categories of respiratory, cardiac, central nervous system and multisystem involvement. All other causes were grouped under miscellaneous, including accidental extubation and surgical bleeding.
RESULTS
Demographic data showed a mean age of 62±5.5 years. The number of male patients was almost three times more than females. Patients, who underwent a CABG, were 933(75.91%), including 5(0.4%) patients who had had a redo procedure. Nine patients (0.73%) had severe renal impairment and underwent off pump bypass.
A total of 47(3.82%) patients required reintubation after weaning off ventilation. Fourteen (29.78%) patients were reintubated within 5-10 hours after extubation, but 18(38.29%) patients tolerated the extubation trial well for the first 24 hours and needed reintubation afterwards (Table-4).
Table 3: Reintubation data*
| Variable | Total No.
of patients |
Reintubation
N(%) |
|||
| Patients | 1229 | 47(3.82) | |||
| Sex | Male | 864(70.30) | 32(3.70) | ||
| Female | 365(29.69) | 15(4.10) | |||
| Surgical Procedure | |||||
| Single valve replacement
Double valve replacement CABG Coronary + valve replacement |
152(12.36)
65(5.28) 933(75.91) 79(6.42) |
18(11.84)
5(10.63) 20(2.14) 4(5.06) |
|||
| Special Monitoring | |||||
| Pulmonary artery pressure | 43(3.49) | 11(25.58) | |||
| PCWP** | 35(2.84) | 5(14.82) | |||
| Left atrial pressure | 17(1.38) | 7(41.17) | |||
| Initial mode of ventilation | |||||
| Volume control | 971(79.00) | 41(87.23) | |||
| Pressure control | 258(20.99) | 6(12.76) | |||
*Data presented as number and percentage
**Pulmonary capillary wedge pressure
Table 4: Time to reintubation
| Time of Reintubation | N(%) |
| Within 24 hours
2nd day 3rd day 4th day 5th day >5 days |
26(55.31)
7(14.89) 4(8.51) 7(14.89) 1(2.12) 2(4.25) 0 |
| Time since last extubation (hrs) | N(%) |
| 0-1
2-4 5-10 11-24 >24 |
8(17.02)
5(10.63) 14(29.78) 2(4.25) 18(38.29) |
Twenty six (55.31%) patients were reintubated because of impending respiratory failure due to various reasons but respiratory muscles weakness and hypoventilation were the most important cause (Table 5). Only 6 (12.76%) patients had cardiovascular reason for reintubation, where hemodynamic instability and hypotension were the important responsible factors. Five patients (10.6%) were re-intubated because of impaired conscious level that deteriorated after extubation. Only 2(4.25%) patients were extubated accidently and were reintubated immediately.
The decision to reintubate was made on overall condition of the patient and the cause for reintubation was assigned to the physiological system that was predominantly involved in the failure. Only 4(8.5%) patients had a significant involvement of more than one body system and the cause was assigned to multi-organ failure category. The most common combination of multi-organ involvement was impending respiratory failure together with impaired conscious level.
Table 5: Causes of reintubation
| Causes | N(%) |
| Impending respiratory failure:
Due to Pneumonia / excessive secretions, non cardiac pulmonary edema, lung collapse, aspiration, bronchospasm, respiratory muscle weakness, upper airway obstruction, hypoventilation syndrome and kinked / blocked tube. |
26(55.31) |
| Cardiovascular:
Severe myocardial ischemia or acute Infarction, severe arrhythmia with Hemodynamic instability, severe hypotension (low output syndrome), congestive heart failure and cardiac arrest. |
6(12.76) |
| Impaired conscious level | 5(10.6) |
| Accidental extubation | 2(4.25) |
| Surgical bleeding | 2(4.25) |
| Multi organ involvement | 4(8.5) |
| Miscellaneous | 2(4.25) |
| Total | 47(100) |
Eighteen patients (38.29 %) that were reintubated once or more than once eventually died. None of them had a tracheostomy because they all died for various reasons within two weeks of reintubation. The cause of death determination was beyond the scope of this study; hence, has been ignored.
Five (10.63%) patients, needed reintubation more than once (Table 3). The incidence of reintubation was not different between male and female patients and corresponded closely to their ratio. We found a higher incidence of reintubation, 18/152 (11.84 %) and 5/65 (10.63%), in single and double valve replacement surgery respectively. The incidence was much lower [20/933 (2.14%)] among CABG patients.
DISCUSSION
We admitted 1229 consecutive patients after cardiac surgery in our ICU over a period of 7 months and studied them prospectively. A total of 47(3.82%) patients failed the extubation trial. Patients undergone a single or double valve surgery had a higher incidence of reintubation in comparison to CABG surgery. The incidence of reintubation was 4/79(5.06%) in patients who had CABG together with a valve replacement.
The higher incidence of reintubation among the valve replacement surgery indicates some correlation between the extubation failure and valve surgery. The exact cause is unclear but it is known that pulmonary functions might deteriorate in the immediate postoperative period and might take time to return to the preoperative values8. The possible mechanism could be the poor compliance of the lungs to accommodate the corrected cardiac output after valve surgery. The reported incidence of persistent pleural effusion for weeks after valve replacement surgery is 45%9 and that could have been contributed to pulmonary malfunction and subsequent need for reintubation in our valve replacement patients.
Our overall incidence (3.82%) of reintubation was almost half of the reported incidence (6.6%) after cardiac surgery4. The reasons of this difference may be related either to the difference in the type of surgery or to a difference in the policy of fast track protocol at some centers, in an attempt to reduce the ICU stay and cost10.
The most common (55.31%) cause for reintubation in our study was impending respiratory failure that manifested with increased work of breathing, accessory muscle use, hypoxia and/or hypercapnea, hypoventilation and respiratory acidosis, especially for those who were reintubated within the first 24 hours. Half of our reintubated patients developed pneumonia. In a case control study, the incidence of pneumonia was significantly higher (47%vs10%) in patients needing reintubation11. Dries and colleagues also found an increased incidence of nosocomial pneumonia in patients who failed extubation trial12, which confirms our findings.
Pulmonary edema and upper airway obstruction were among the important respiratory causes for reintubation, especially for those who were reintubated after the second day of extubation. Interestingly, causes related to airway patency and secretions manifested only after extubation.
The incidence of asymptomatic myocardial ischemia has been reported to be 52% after CABG13. In our study 6/47 (12.76%) of the patients had a cardiac reason for reintubation, where myocardial ischemia or acute infarction were the common reasons, that led to low output syndrome and heart failure among CABG patients, while pulmonary hypertension was the important reason in the valve replacement surgical patients.
It is well known that patients, who undergo myocardial revascularization procedures, are particularly prone to stroke, encephalopathy and other neurologic dysfunction, because they are relatively old and have atherosclerotic disease. They are also subject to cerebral embolization and cerebral hyperthermia after the discontinuation of cardiopulmonary bypass14, 15. We found impaired conscious level (10.6%) to be the third important reason for reintubation in our study. Two of those patients ultimately developed stoke and died later on.
CONCLUSION
Endotracheal reintubation is not uncommon among critically ill patients after open heart surgeries. The incidence was higher in patients undergone valve replacement surgery in comparison to CABG surgery. Impending respiratory failure, cardiovascular (hemodynamic) instability and impaired conscious level were the most important indications for reintubation.
REFERENCES
- Kurt M, Boeken U, Litmathe J, Feindt P, Gams E. Oxygenation failure after cardiac surgery: Early reintubation versus treatment by nasal continuous positive airway pressure (NCPAP) or non-invasive positive pressure ventilation (NPPV). Monaldi Arch chest Dis 2008;70:71-5.
- Demling, RH, Read T, Lind LJ, Flanagan HL. Incidence and morbidity of extubation failure in surgical intensive care patients. Crit. Care Med;16:573-7.
- Epstein K, Ciubotaru RL. Independent effects of etiology of failure and time to reintubation on outcome for patients failing extubation Am J Respir. Crit Care Med1998;158(2):489-93.
- Rady, Mohamed Y, Ryan, Thomas MB. Perioperative predictors of extubation failure and the effect on clinical outcome after cardiac surgery. Crit Care Med1999;27(2):340-47.
- Gowardman JR, Huntington D, Whiting J. The effect of extubation failure on outcome in a multidisciplinary Australian intensive care unit. Crit Care Resus 2006;8:328–33.
- Jordi R, Emili D, Marta R, Jordi V. Risk factors for developing pneumonia within 48 Hours of Intubation. Am. J. Resir. Crit. Care Med 1999;159(6):1742-46.
- Sibu P, Saha, Norma L, Cindy B, Victor A, Ferraris. Advanced Care for Patients after Coronary artery bypass graft. Inter J Ang 2005;14:141-43.
- Mustafa KY, Nour MM, Shuhaiber H, Yousof AM. Pulmonary function before and sequentially after valve replacement surgery with correlation to preoperative hemodynamic data. Am Rev Respir Dis1984;130(3):400-6.
- Moujahed L, Richard B, Brigitte D, François M, Louis PB. Pleural Effusions Following Cardiac Surgery. Prevalence, Risk Factors, and Clinical Features. CHEST 2009;136(6):1604-11.
- Reyes A, Vega G, Blancas R, Morato B, Moreno JL, Torrecilla C, Cereijo E. Early vs conventional extubation after cardiac surgery with cardiopulmonary bypass. Chest 1997;112(1):193-201.
- Torres A, Gatell JM, Aznar E, el Ebiary M, Puig DL, Gonzalez J. Reintubation increases the risk of nosocomial pneumonia in patients needing mechanical ventilation. Am J Respir Crit Care Med 1995;152:137–41.
- Dries DJ, McGonigal MD, Malian MS, Bor BJ, Sullivan C. Protocol-driven ventilator weaning reduces use of mechanical ventilation, rate of early reintubation and ventilator-associated pneumonia. J Trauma 2004;56:943–51.
- Smith, Randall C, Leung, Jacqueline M, Mangano, Dennis T. Postoperative myocardial ischemia in patients undergoing coronary artery bypass graft surgery. Anesthesiology 1991;74:464-73.
- Mora CT, Murkin JM. The central nervous system responses to cardiopulmonary bypass. In: Mora CT, ed. Cardiopulmonary bypass: principles and techniques of extracorporeal circulation. New York: Springer-Verlag. 1995: pp114-46.
- Herskowitz A, Mangano DT. The inflammatory cascade: a final common pathway for perioperative injury? Anesthesiology 1996;85:454-57.
Tags: http://www.staying-awake.org, http://www.whyhcg.com, http://www.myprovigil.com
